1、高低溫試驗設備。在高溫試驗中，如果溫度變化達不到試驗溫度值，可以對電氣系統進行檢查，逐個排除故障。如果溫度上升緩慢，檢查空氣循環系統，看看空氣循環的風門是否正常打開。否則，檢查電機的空氣循環手術是否正常。如果溫度超調嚴重，需要設置PID整定參數，如果溫度直接升高，保護超溫，如果控制器失效，須更換控制儀表。
2、試驗運行中，當高低溫試驗設備突然故障時，控制儀表上出現相應的故障顯示提示和聲音報警提示。操作者在操作和使用設備時，可根據故障排除章節快速檢查故障類型，然后請人員排除故障，確保測試正常。其他環境試驗設備在使用過程中還會出現其他現象，要對這些現象進行分析和消除。定期維護環境試驗設備，定期清洗制冷系統冷凝器，按說明書要求對移動部件進行潤滑，定期維護和檢查電氣控制系統等.
3、如果高低溫度測試儀器的低溫不符合測試指標，則應觀察溫度變化，在溫度達到一定值后，是緩慢下降還是上升。對于前者，應在低溫測試前檢查工作室內是否干燥，然后將測試樣品放入工作室內進行進一步測試。測試樣本在房間工作產品是否放置太多,所以工作室的空氣不能流通,消除上述原因后,要考慮是否在制冷系統故障,所以要問儀器廠家的人員進行維護。后一種現象是設備使用環境差造成的。設備的環境溫度和位置(箱與墻的距離)應符合要求(設備使用說明書中規定)。
4、在濕熱高低溫箱的試驗中，實際濕度或實際濕度與目標濕度相差較大，數值要低得多。前一種現象:可能是濕球傳感器上的紗布干燥引起的，所以要檢查濕球傳感器的水箱是否缺水。水箱內水位由水位控制器自動控制，檢查水位控制器供水是否正常，供水系統供水是否正常，水位控制器工作是否正常。另一種可能是濕球紗布由于使用時間長或供水水質純凈而變硬，使紗布無法吸水和干燥。只要更換或清洗紗布，上述現象就可以消除。后者的現象是加濕系統不工作。檢查加濕系統供水系統，供水系統是否有一定量的水，加濕鍋爐水位控制是否正常，加濕鍋爐水位是否正常。如以上各項正常，應檢查電氣控制系統，由維修人員進行維修。
0769-8880 8158
